EloVac®-P

EloVac®-P is a compact, skid-mounted vacuum degassing technology for digested sludge with simultaneous phosphate precipitation, which improves dewatering and reduces the phosphate return load. This technology is particularly beneficial for any anaerobic digestion plant with struvite scaling issues looking to improve dewatering and reduce polymer consumption.

Unique Benefits

Improve dewatering

High phosphate contents in the digested sludge for example at Bio-P plants increases the water binding capacity of EPS and proteins. Precipitating the dissolved phosphate reduces the water binding capacity and therefore increases dewaterability of the digested sludge. Samples from digested sludge in the Lingen WWTP, Germany before and after EloVac®-P were examined. The TR(A)-parameter assessing the achievable dewatering result of sludge (method developed by Dr. Julia Kopp, wastewater treatment engineer ) showed a significant increase in the dewatering result of more than 5% points. Based on these results, disposal cost savings of approximately 20% can be attributed to the vacuum degassing with P-precipitation as a stand-alone technology.

Prevent struvite scaling

Vacuum degassing slightly raises the pH of the digested sludge and with the addition of magnesium chloride; the controlled struvite precipitation takes places in the reactor tank without growth or separation of the struvite. The micro-crystals are the size of a fine sand, which means that they do not attach to pipes, tanks or dewatering equipment. Because the pH goes up only slightly (<8) and the concentration of phosphate is reduced considerably, the risk of struvite formation downstream is mitigated.

Compact system with easy installation

Compared to conventional technologies, the approach of EloVac®-P is different in the precipitation of the phosphate: achieving no growth of the precipitates and no separation of the crystals. Therefore, the benefits of this approach are unique: a very small tank reactor volume (approximately 50 times smaller than the standard technologies) because the retention time for the chemical reaction takes place in seconds rather than hours. Additionally with EloVac®-P we avoid wear of the dewatering
equipment due to abrasive struvite crystals.

EloVac®-P is a modular system that can handle any plant size. The different models of EloVac®-P range from 10 m³/h to 50 m³/h throughput of digested sludge. The system comes pre-assembled and it is skid mounted so there is minimal on-site construction required.

Additional biogas production and reduction of greenhouse gas emissions

Conventional phosphate precipitation processes raise the pH of the digested sludge either by adding caustic soda, thus consuming chemicals, or by aeration, and therefore stripping CO₂. With aeration, not only is CO₂stripped, but also methane is released into the atmosphere. With EloVac®-P, the vacuum degassing not only causes an increase in the pH by withdrawing CO₂, but the vacuum captures the biogas that is not “diluted” with air, which prevents methane being emitted into the atmosphere. The additional biogas can be then utilised to operate the unit, making EloVac®-P an energy positive system.

Improve the quality of the biosolids cake

The quality of biosolids produces at the plant as a fertiliser for agricultural and land cultivation improves with EloVac®-P because the miniscule struvite crystals remain in the dewatered cake.

See how it works

  1. Sludge is fed continuously into the degassing reactor tank.
  2. A vacuum pump extracts the methane and CO2 from the digested sludge to raise the pH in the reactor tank. The vacuumed gas enables an energy-positive operation by capturing additional biogas, while reducing greenhouse gas emissions.
  3. MgCl2 is added to the reactor tank. With the higher pH, the controlled struvite precipitation takes place without crystal growth. Retention time ~ 10 minutes.
  4. Continuous discharge of degassed sludge with the precipitated struvite to dewatering.

EloVac®-P footprint in relation to the digester

EloVac® is scalable

See what customers have to say

Quote from Mr. Hüer, Management, treatment works of Lingen (EMS):

‘After implementing the vacuum degassing system with simultaneous phosphate precipitation: EloVac-P, we no longer have problems with struvite scaling. With EloVac-P we not only avoid operational problems, but also save on disposal and polymer costs.’

COMPLEMENTARY TECHNOLOGIES

Is EloVac®-P right for your treatment plant?

- Are disposal costs a major expense?
- Do you have struvite scaling issues?
- Do you have Bio-P?
- Do you have goals to improve the carbon footprint of your operation?
- Is the quality of the biosolids cake relevant to you?

To learn more about EloVac®-P, please complete the information below. Because every sludge is different, we also offer lab tests at your facility to predict the expected benefits vacuum degassing and P-precipitation will have on dewatering, P-reduction and expected additional gas volume that can be withdrawn from your digested sludge.

RECEIVE A FREE EloVac®-P EVALUATION

What is the sum of 4 and 8?

To receive a free EloVac®-P evaluation, please complete the form below and we will get in touch with you:

Essential data for EloVac®-P evaluation:

tDS / day
m³/day
tDS/day
 
%
mg/l
Is hygienisation of the digested sludge a requirement in your project?
Data privacy declaration of consent*

Contact us

Maria Dittmann
Jahnstraße 36
88214 Ravensburg
Tel. +49 751 359785-14